×

Nonlinear waves in counter-current gas-liquid film flow. (English) Zbl 1225.76044

Summary: We investigate the dynamics of a thin laminar liquid film flowing under gravity down the lower wall of an inclined channel when turbulent gas flows above the film. The solution of the full system of equations describing the gas-liquid flow faces serious technical difficulties. However, a number of assumptions allow isolating the gas problem and solving it independently by treating the interface as a solid wall. This permits finding the perturbations to pressure and tangential stresses at the interface imposed by the turbulent gas in closed form. We then analyse the liquid film flow under the influence of these perturbations and derive a hierarchy of model equations describing the dynamics of the interface, i.e. boundary-layer equations, a long-wave model and a weakly nonlinear model, which turns out to be the Kuramoto-Sivashinsky equation with an additional term due to the presence of the turbulent gas. This additional term is dispersive and destabilising (for the counter-current case; stabilizing in the co-current case). We also combine the long-wave approximation with a weighted-residual technique to obtain an integral-boundary-layer approximation that is valid for moderately large values of the Reynolds number. This model is then used for a systematic investigation of the flooding phenomenon observed in various experiments: as the gas flow rate is increased, the initially downward-falling film starts to travel upwards while just before the wave reversal the amplitude of the waves grows rapidly. We confirm the existence of large-amplitude stationary waves by computing periodic travelling waves for the integral-boundary-layer approximation and we corroborate our travelling-wave results by time-dependent computations.

MSC:

76A20 Thin fluid films
76T10 Liquid-gas two-phase flows, bubbly flows
Full Text: DOI

References:

[1] DOI: 10.1063/1.1426103 · Zbl 1184.76467 · doi:10.1063/1.1426103
[2] DOI: 10.1017/S0022112005005422 · Zbl 1080.76009 · doi:10.1017/S0022112005005422
[3] DOI: 10.1016/j.ijmultiphaseflow.2005.07.005 · Zbl 1135.76406 · doi:10.1016/j.ijmultiphaseflow.2005.07.005
[4] DOI: 10.1007/s100510050550 · doi:10.1007/s100510050550
[5] DOI: 10.1017/S0022112007009378 · Zbl 1159.76308 · doi:10.1017/S0022112007009378
[6] DOI: 10.1017/S0022112083002943 · Zbl 0525.76016 · doi:10.1017/S0022112083002943
[7] DOI: 10.1017/S0022112009008155 · Zbl 1183.76014 · doi:10.1017/S0022112009008155
[8] DOI: 10.1007/BF01090346 · Zbl 0478.76055 · doi:10.1007/BF01090346
[9] Schlichting, Boundary-Layer Theory (2000) · doi:10.1007/978-3-642-85829-1
[10] DOI: 10.1007/BF01050808 · doi:10.1007/BF01050808
[11] DOI: 10.1017/S0022112004003179 · Zbl 1142.76380 · doi:10.1017/S0022112004003179
[12] DOI: 10.1103/PhysRevLett.103.234501 · doi:10.1103/PhysRevLett.103.234501
[13] DOI: 10.1017/S0022112005005446 · Zbl 1080.76010 · doi:10.1017/S0022112005005446
[14] Dukler, Annu. Rep. (1979)
[15] DOI: 10.1017/S0022112008001225 · Zbl 1151.76378 · doi:10.1017/S0022112008001225
[16] DOI: 10.1103/PhysRevE.78.036312 · doi:10.1103/PhysRevE.78.036312
[17] DOI: 10.1103/RevModPhys.81.1131 · doi:10.1103/RevModPhys.81.1131
[18] DOI: 10.1016/0301-9322(91)90055-8 · Zbl 1134.76638 · doi:10.1016/0301-9322(91)90055-8
[19] DOI: 10.1017/S0022112093001521 · doi:10.1017/S0022112093001521
[20] DOI: 10.1016/j.ces.2008.05.003 · doi:10.1016/j.ces.2008.05.003
[21] Chang, Complex Wave Dynamics on Thin Films. (2002)
[22] DOI: 10.1063/1.1485766 · Zbl 1185.76289 · doi:10.1063/1.1485766
[23] DOI: 10.1017/S0022112059000568 · Zbl 0093.19106 · doi:10.1017/S0022112059000568
[24] DOI: 10.1103/RevModPhys.69.931 · doi:10.1103/RevModPhys.69.931
[25] DOI: 10.1017/S0022112057000373 · Zbl 0078.18003 · doi:10.1017/S0022112057000373
[26] DOI: 10.1007/BF01025515 · Zbl 0314.76033 · doi:10.1007/BF01025515
[27] DOI: 10.1017/S0022112077000524 · doi:10.1017/S0022112077000524
[28] DOI: 10.1016/j.ces.2005.04.014 · doi:10.1016/j.ces.2005.04.014
[29] DOI: 10.1017/S0022112057000567 · Zbl 0078.40705 · doi:10.1017/S0022112057000567
[30] DOI: 10.1016/S0301-9322(99)00098-1 · Zbl 1137.76797 · doi:10.1016/S0301-9322(99)00098-1
[31] DOI: 10.1016/j.ces.2007.12.030 · doi:10.1016/j.ces.2007.12.030
[32] DOI: 10.1016/S0301-9322(99)00097-X · Zbl 1137.76796 · doi:10.1016/S0301-9322(99)00097-X
[33] DOI: 10.1016/0301-9322(85)90022-9 · doi:10.1016/0301-9322(85)90022-9
[34] DOI: 10.1063/1.1706737 · Zbl 0116.19102 · doi:10.1063/1.1706737
[35] DOI: 10.1016/0301-9322(84)90082-X · Zbl 0597.76092 · doi:10.1016/0301-9322(84)90082-X
[36] DOI: 10.3176/proc.2010.2.12 · Zbl 1194.35392 · doi:10.3176/proc.2010.2.12
[37] DOI: 10.1002/aic.11506 · doi:10.1002/aic.11506
[38] DOI: 10.1016/j.physd.2010.07.011 · Zbl 1235.37030 · doi:10.1016/j.physd.2010.07.011
[39] DOI: 10.1017/S0022112074001704 · Zbl 0283.76035 · doi:10.1017/S0022112074001704
[40] Trifonov, AIChE J. 56 pp 1975– (2010)
[41] DOI: 10.1016/0017-9310(84)90152-2 · doi:10.1016/0017-9310(84)90152-2
[42] DOI: 10.1017/S0022112007008476 · Zbl 1128.76006 · doi:10.1017/S0022112007008476
[43] DOI: 10.1016/0029-5493(94)90092-2 · doi:10.1016/0029-5493(94)90092-2
[44] DOI: 10.1007/s10665-004-1016-x · Zbl 1074.76009 · doi:10.1007/s10665-004-1016-x
[45] DOI: 10.1103/PhysRevLett.51.381 · doi:10.1103/PhysRevLett.51.381
[46] DOI: 10.1063/1.1767835 · Zbl 1186.76536 · doi:10.1063/1.1767835
[47] DOI: 10.1016/0009-2509(78)80020-7 · doi:10.1016/0009-2509(78)80020-7
[48] Kapitza, Collected Papers of P. L. Kapitza (1965) pp 662– (1948)
[49] DOI: 10.1007/978-3-211-69808-2 · Zbl 1117.76002 · doi:10.1007/978-3-211-69808-2
[50] DOI: 10.1115/1.2822691 · doi:10.1115/1.2822691
[51] DOI: 10.1017/S0022112002003014 · Zbl 1081.76028 · doi:10.1017/S0022112002003014
[52] Stainthorp, Trans. Inst. Chem. Engrs 45 pp 372– (1967)
[53] DOI: 10.1017/S0022112003005809 · Zbl 1063.76030 · doi:10.1017/S0022112003005809
[54] DOI: 10.1007/BF01024797 · doi:10.1007/BF01024797
[55] DOI: 10.1063/1.857553 · Zbl 1222.76103 · doi:10.1063/1.857553
[56] DOI: 10.1017/S0022112065000770 · doi:10.1017/S0022112065000770
[57] DOI: 10.1016/0301-9322(95)00069-0 · Zbl 1135.76448 · doi:10.1016/0301-9322(95)00069-0
[58] Semyonov, J. Tech. Phys. (in Russian) 14 pp 427– (1944)
[59] Homsy, Lectures in Applied Mathematics: Nonlinear Wave Motion pp 191– (1974)
[60] DOI: 10.1007/s100510051137 · doi:10.1007/s100510051137
This reference list is based on information provided by the publisher or from digital mathematics libraries. Its items are heuristically matched to zbMATH identifiers and may contain data conversion errors. In some cases that data have been complemented/enhanced by data from zbMATH Open. This attempts to reflect the references listed in the original paper as accurately as possible without claiming completeness or a perfect matching.